View CLAA104XA01CW_7874440.PDF datasheet online --- IC-ON-LINE

Datasheet File OCR Text:

c c h h u u n n g g h h w w a a p p i i c c t t u u r r e e t t u u b b e e s s , , l l t t d d . . p p r r o o d d u u c c t t s s p p e e c c i i f f i i c c a a t t i i o o n n to : rb date : 080814 accepted by : (v1.3) approved by checked by prepared by
u?/ ? _ prepared by : product planning management division small & medium tft product business unit chunghwa picture tubes, ltd. 1127 hopin rd., padeh, taoyuan, taiwan 334, r.o.c. tel: +886-3-3675151 fax: +886-3-377--3858 doc.no: spec_CLAA104XA01CW_v1.3_rb_080814 issue date: 2008/06/10 tft lcd CLAA104XA01CW www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 revision status revision notice description page rev. date ver. 0.0 first revision (tentative) 18 2007.12.06 ver. 0.1 modify power consumption(6.2w 6.4w) 4 2008.01.23 modify lamp wire length(50mm 100mm) 15 2008.01.23 ver. 0.2 modify module weight 4 2008.01.28 modify inverter frequency 9 2008.01.28 ver. 0.3 modify power consumption 4 2008.02.04 modify absolute maximum ratings 5 2008.02.04 modify electrical characteristics 7 2008.02.04 modify tft-lcd current consumption 8 2008.02.04 modify backlight 9 2008.02.04 modify interface connection 10 2008.02.04 modify timing specification 11 2008.02.04 modify optical characteristics 16 2008.02.04 modify esd test 18 2008.02.04 ver. 1.0 modify power consumption 4 2008.03.07 modify absolute maximum ratings 5 2008.03.07 modify tft-lcd current consumption 8 2008.03.07 modify backlight 9 2008.03.07 modify interface connection 10 2008.03.07 modify optical characteristics 16 2008.03.07 ver. 1.1 modify power consumption 4 2008.03.12 modify absolute maximum ratings 5 2008.03.12 modify backlight 9 2008.03.12 ver. 1.2 modify power consumption 4 2008.03.31 modify absolute maximum ratings 5~6 2008.03.31 modify backlight 9 2008.03.31 modify mechanical dimension 15 2008.03.31 ver. 1.3 modify the general specification table 4 2008.06.10 modify interface connection 10 2008.06.10 modify timing specification 11 2008.06.10 add the mtbf 18 2008.06.10 www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 contents 1. over view .................................................................................................................... ... 4 2. absolute maxi mum ratings ................................................................................... 5 3. electrical characteristi cs................................................................................. 7 3.1 tft lcd ............................................................................................................................... ..... 7 3.2 tft-lcd current consumption ............................................................................................ 8 3.3 power esignal sequence ....................................................................................................... 8 3.4 backlight ..................................................................................................................................... 9 4. interface connect ion........................................................................................... 10 4.1 cn1 ............................................................................................................................... ........... 10 5. input signal(de only mo de) ................................................................................. 11 5.1 timing specification .............................................................................................................. 11 5.2 timing sequence(timing chart )........................................................................................... 11 6. block diagram ......................................................................................................... 14 7. mechanical dimension ........................................................................................... 15 7.1 front side ............................................................................................................................... 15 7.2 rear side ............................................................................................................................... . 15 8. optical charact eristi cs ..................................................................................... 16 9. reliability t est ........................................................................................................ 18 9-1. temperature and humidity .................................................................................................. 18 9.2. shock and vibration ............................................................................................................. 18 9.3. esd test ............................................................................................................................... . 18 9.4 judgment standard ................................................................................................................ 18 www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 1. overview CLAA104XA01CW is 10.4? color tft-lcd (thin film transistor liquid crystal display) module composed of lcd panel, driver ics ,control circuit and backlight. by applying 1024768 images are displayed on the 10.4? di agonal screen. display 262k colors by 6 bit r.g.b signal input. general specification are summa rized in the following table: item specification display area (mm) 211.2(w)158.4(h) (10.4-inch diagonal) number of pixels 1024(h) 3(rgb) 768(v) pixel pitch (mm) 0.20625 x0. 20625 color pixel arrangement rgb vertical stripe display mode normally white, tn number of colors 262,144 optimum viewing angle 6 o?clock brightness (cd/m^2) 300nit(typ) response time (ms) 25ms (typ) 140 degree (horizontal.) viewing angle(bl on,cr 10) 120 degree (vertical) power consumption 6.41w(typ) electrical interface(data) lvds module size (mm) 236(w)174.3(h)7.4(d) module weight (g) 380(typ) backlight unit ccfl surface treatment anti-glare hardness:3h www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 2. absolute maximum ratings the following are maximun values which, if exceeded, may cause faulty operation or damage to the unit. item symbol min. max. unit note power supply voltage vcc -0.3 4.0 v singal input voltage rxin0+ ~ rxin2+ rxin0- ~ rxin2- rx clk in +/- -0.3 vcc+0.3 v lamp voltage vl 729 946 vrms lamp current il 4 8 marms ?note 4 ? lamp frequency fl 40 80 khz ?note 4 ? vesdc -200 200 v static electricity vesdm -15k 15k v ?note2 ? icc rush current irush -- 1 a ?note 3 ? operation temperature t op -20 70
?note 1 ? storage temperature t stg -30 80
?note 1 ? discharge time lag td -- 1 sec ?note 6 ? ?note ? ?note1 ? if users use the product out o ff the environmemt operation range ?temperature and humidity ?,it will concern for visual quality. ?note2 ? test condition: iec 61000-4-2 , vesdc jcontact discharge to input connector vesdmjdiscontact discharge to module ?note3 ? the input pulse-current m easurement system as below j vin ( lcd input) 12v 3.3v c1 1uf r1 47k q1 q2 r2 1k c2 10000pf r3 47k c3 1uf crl signal www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 control signal:high(+3.3v) low(gnd) supply voltage of rising time should be from r3 and c2 tune to 550 us. ?note 4 ? table of specifications are definition of single lamp . ?note 5 ? the frequency is operated in the range, will not influence the life of lamp and display characteristic. ?note 6 ? the time needed to start discharge when the over star ting lamp voltage is continuously applied to both ends of the lamp. before testing, the lamp is le ft in the dark room (ambient temperature : 252 ? , ambient illuminance : less than 0.1lux) for 24hr after lighted for 1 minute at rated lamp current. the testing shall be conducted in the dark room. and the sealing side shall be connected to high voltage side. (ambient temperature :252 ? , ambient illuminance : less than 0.1lux). the minimum safety time for the inverter need over the maximum time for the start discharge . 3jtjoh 5jnf 7*/ 7*/ 7*/ (/% ?t www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 3. electrical characteristics 3.1 tft lcd ta=25
item symbol min. typ max. unit note power supply voltage for lcd v cc 3.0 3.3 3.6 v common mode voltage vcm 1.08 1.2 1.32 v *1) differential input voltage zvid z 250 350 450 mv *1) threshold voltage(high) vth - - 100 mv *1) vcm=+1.2v logic input voltage (lvds:in+,in-) threshold voltage(low) vtl -100 - - mv *1) 3fnbsltj *1)lvds signal |vid| = |vth ? vtl|, vcm =( vth + vtl)/2 www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 3.2 tft-lcd current consumption item symbol min type max unit notes lcd power current icc -- 420 600 ma *1) remarks: *1)typical: under 64 gray pattern maximum: under black pattern 3.3 power esignal sequence t1 10ms 1 sec t5 0 ?50mst2 200ms t6 0 ? t3 50ms 200ms t7 0 ? t4 10ms data t1 t2 t3 3.0v 3.0v 0.3v vin=3.3v 0.3v 0.3v t4 t5 lcd power supply logic signal t6 t7 backlight power supply vl data: rgb data, dclk, dena www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 #bdlmjhiu ta=25
item symbol min typ max unit note lamp current il 5.5 6.0 6.5 marms lamp voltage vl 752 835 919 vrms *1) i il=6.0ma inverter frequency fi 40 50 60 khz *1).*2) - - 1400 vrms ta=25
*1).3) - - 1500 vrms ta=0
*1).3) start lamp voltage vs 1700 vrms ta=-20
*1).3) lamp life time it 20,000 30,000 hr *1).4),il@6.0ma turn on and off life 100,000 times *1).5),il@6.0ma continuous openation time cycle 20 s. if the driving waveform of lamp is asymmetric, the distribution of mercury inside the lamp tube will become unequally or will deplete the ar gas in it. then it may cause the abnormal phenomenon of lighting-up. therefore, designers have to try their best to for fill the conditions under the inverter designing-stage as below: z the degrees of unbalance j ?10 % z the ratio of wave height j? 2 10 % [note] *1) table of specifications are definition of single lamp. *2) 1.frequency in this range , the characterisitics of electric and optics can main tain in 10% except hues. 2.lamp frequency of inverter may produce in terference with horizontal synchronous frequency (or vertical synchronous frequency),and this may cause ripple noise on the display. therefore, please adjust inverter frequency, and keep inverter as far from module as possible or use electronic shielding between inverter and module to avoid the interference. *3)1.starting lamp voltage: vs = initial value vs 2.definition of starting lamp voltage means max. voltage of starting lamp. we suggest the inverter starting voltage greater then max. voltage of star ting lamp to certify starting lamp stability. *4) definition of the lamp life time jluminance(l) under 50% of specif ication starting lamp voltage. *5) test condition of turn on and off life : turn on and off lamp at il=8.0ma and (ta=25 5
). the frequency is 10 sec.(on )on/ 10 sec. (off ) and go on 100,000 times repeatedly. ip i-p i p jhigh side peak i-p jlow side peak a jthe degrees of unbalance = zip ? i-p z/ irms 100 (%) b jthe ratio of wave height = ip (or i-p) / irms www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 4. interface connection 4.1 cn1 lcd connector (30pin) jstarconndp/n j093f30 or other of the same class link connector jfi-x30h(jae,link type) or other of the same class pin no. symbol description 1 gnd ground 2 v +3.3v power 3 v +3.3v power 4 nc nc 5 nc nc 6 nc nc 7 gnd ground 8 rxin0- lvds signal(-)?channel 0 9 rxin0+ lvds signal(+)?channel 0 10 gnd ground 11 rxin1- lvds signal(-)?channel 1 12 rxin1+ lvds signal(+)?channel 1 13 gnd ground 14 rxin2- lvds signal(-)?channel 2 15 rxin2+ lvds signal(+)?channel 2 16 gnd ground 17 rxclkin- lvds clock signal(-) 18 rxclkin+ lvds clock signal(+) 19 gnd ground 20 nc nc 21 nc nc 22 gnd ground 23 gnd ground 24 nc nc 25 nc nc 26 nc nc 27 nc nc 27 nc nc 29 nc nc 30 nc nc remarks j 1) nc pin : don`t connect any signal or ground. 2) gnd pin : grounding pin,don`t to floating. www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 5. input signal(de only mode) 5.1 timing specification item symbol min typ max unit lvds input signal sequence clk frequency fclkin 51 65 71 mhz horizontal total time t h 1160 1344 1350 tclk horizontal effective time t ha 1024 tclk horizontal horizontal blank time t hb 136 320 326 tclk frame fv 55 60 65 hz vertical total time t v 790 806 810 t h vertical effectivetime t va 768 t h lcd input signal sequence ?input lvds transmitter ? dena vertical vertical blank time t vb 22 38 42 t h [note] *1) data is latched during dclk falling period.(lvds mode) *2) dena (data enable) usually is positive. 5.2 timing sequence(timing chart
5.2.1 horizontal timing sequence www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 5.2.2 vertical timing sequence 5.2.3 lvds input data mapping www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 5.2.4 color data assignment color input r data g data b data data r5 r4 r3 r2 r1 r0 g5 g4 g3 g2 g1 g0 b5 b4 b3 b2 b1 b0 msb lsb msb lsb msb lsb black 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 red(63) 1 1 1 1 1 1 0 0 0 0 0 0 0 0 0 0 0 0 green(63) 0 0 0 0 0 0 1 1 1 1 1 1 0 0 0 0 0 0 blue(63) 0 0 0 0 0 0 0 0 0 0 0 0 1 1 1 1 1 1 cyan 0 0 0 0 0 0 1 1 1 1 1 1 1 1 1 1 1 1 magenta 1 1 1 1 1 1 0 0 0 0 0 0 1 1 1 1 1 1 yellow 1 1 1 1 1 1 1 1 1 1 1 1 0 0 0 0 0 0 basic color white 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 red(0) 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 red(1) 0 0 0 0 0 1 0 0 0 0 0 0 0 0 0 0 0 0 red(2) 0 0 0 0 1 0 0 0 0 0 0 0 0 0 0 0 0 0 red(62) 1 1 1 1 1 0 0 0 0 0 0 0 0 0 0 0 0 0 red red(63) 1 1 1 1 1 1 0 0 0 0 0 0 0 0 0 0 0 0 green(0) 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 green(1) 0 0 0 0 0 0 0 0 0 0 0 1 0 0 0 0 0 0 green(2) 0 0 0 0 0 0 0 0 0 0 1 0 0 0 0 0 0 0 green(62) 0 0 0 0 0 0 1 1 1 1 1 0 0 0 0 0 0 0 green green(63) 0 0 0 0 0 0 1 1 1 1 1 1 0 0 0 0 0 0 blue(0) 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 blue(1) 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1 blue(2) 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 1 0 blue(62) 0 0 0 0 0 0 0 0 0 0 0 0 1 1 1 1 1 0 blue blue(63) 0 0 0 0 0 0 0 0 0 0 0 0 1 1 1 1 1 1 remark t (1)definition of gray scale color(n) jn is series of gray scale. the more n value is the bright gray scale. (2)data:1-high,0-low www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 6. block diagram gate driver dc/dc t-con gamma ccfl black light source1 driver 1024 rgb 768 tft lcd panel source2 driver source3 driver www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 7. mechanical dimension 7.1 front side [u nit jmm] remark jgeneral tolerance j0.3mm 7.2 rear side [unit jmm] remark jgeneral tolerance j0.3mm www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 8. optical characteristics ta = 25c, vcc=3.3v item symbol condition min. typ. max. unit remarks constrast ratio cr point-5 ? -- 500 -- -- *1)*2)*3) luminance(cen) lw point-5 ? 240 300 -- cd/m 2 *1)*3) luminance uniformity ?l 70 80 - % *1)*3) response time (white - black) tr +tf point-5 ? 25 ms *1)*3)*5) horizontal c 130 140 -- *1)*2)*4) viewing angle vertical c cr10 point-5 110 120 -- *1)*2)*4) white wx wy 0.273 0.289 0.313 0.329 0.353 0.369 red rx ry 0.545 0.286 0.585 0.326 0.625 0.366 green gx gy 0.264 0.550 0.304 0.590 0.344 0.630 color coordinate blue bx by point-5 0.116 0.082 0.156 0.122 0.196 0.162 -- *1)*3) remark tj *1)measure condition j 25 2

d6010%rh d under10 lux in the dark room.bm-5a (topcon)dviewing angle2 dvcc=3.3v. *2 ?definition of contrast ratio j contrast ratio (cr)= (white) luminance of on (black) luminance of off www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814
%fgjojujpopgmvnjobodfj.fbtvsfxijufmvnjobodfpouifqpj oubtgjhvsf %fgjojujpopg-vnjobodf6ojgps njuz.fbtvsfxijufmvnjobod fpouifqpjou_btgjhvsf ? l = [l(min)/l(max)]100 fig8-1 measuring point *4) definition of viewing angle( , ),refer to fig8-2 as below j fig8-2 definition of viewing angle *5) definition of response time.(white-black) luminance 90% 90% 10% t f t r white(63 th ) black(0) 10% fig8-3 definition of response time(white-black) www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/
cpt chunghwa picture tubes, ltd., cpt confidential /18 spec_CLAA104XA01CW_v1.3_rb_080814 9. reliability test 9-1. temperature and humidity test items conditions high temperature operation 70
d240hrs high temperature storage 80
d240hrs high temperature high humidity operation 60
d90%rh d240hrs low temperature operation -20
d240hrs low temperature storage -30
d240hrs thermal shock(no operation) -30
?0.5hr ?~ 80
(0.5hr) d200 cycles 9.2. shock and vibration test items conditions shock (non-operation) z shock level:980m/s 2 (equel to 100g) z waveform:half sinusoidal wave,6ms. z number of shocks:one shock input in each direction of three mutually perpendicular axes for a total of three shock inputs. vibration (non-operation) z frequency range:8~33.3hz z amplitude:1.3mm,33.3~400hz z vibration:sinusodial wave,perpendicularaxis(both x, z axis:2hrs, y axis 4hrs). z acceleration:2.9g z sweep cycle time:15min 9.3. esd test item condition remark 150pfd330 ? d 8kv&15kv air & contact test *1) esd 200pfd0 ? d200v contact test *2) remarks j *1) lcd glass and metal bezel *2) if connector pins 9.4 mtbf ccfl:with bl j30,000 hrs (typ) lifetimes. 9.5 judgment standard the judgment of the above test should be made as follow: pass:normal display image with no obvious non-uniformity and no line defect.partial transformation of the module parts should be ignored. fail:no display image,obvious non-uniform www.nacen.co.kr www.datasheet.co.kr datasheet pdf - http://www..net/

▲Up To Search▲

Price & Availability of CLAA104XA01CW

	To Download CLAA104XA01CW Datasheet File
If you can't view the Datasheet, Please click here to try to view without PDF Reader .